Safety Data Sheet

According to GHS (Global Harmonized System) - Hazcom 2012
Date Printed (YYYY-MM-DD): 2018-01-31 

Section 1 - Product and Company Information

Product Name: Super Prep Plastic Cleaner (aerosol)
Product Part Number(s):
Recommended Use: The product is used to clean plastic prior to repairing the plastic.
Revision Date (YYYY-MM-DD):

COMPANY IDENTIFICATION:EMERGENCY TELEPHONE NUMBER
Polyvance24 Hour Emergency ContactChemtrec - 1-800-424-9300 (Outside USA 703-527-3887)
1128 Kirk Rd.Customer Information Number256-638-4103 (7AM - 4PM (CST) M-F)
Rainsville, AL 35986
Information Email: info@polyvance.com

Section 2 - Hazards Identification

Appearance:Clear liquid
Odor:Sweet
Hazard Statement:
 DANGER! Extremely flammable aerosol. Causes skin irritation. May cause genetic defects.  

Signal Word:  

DANGER!
Signal Word Hazard:   Flammable gas
GHS Physical Hazard PictogramsGHS Health Hazard PictogramsGHS Environmental Hazard Pictograms

Flammable

Health Hazard
 
Not Applicable

GHS Hazards Statement Codes for This Product

Statement
Type
Statement
Code
Statement Text
Physical H222 Extremely flammable aerosol
Health H315 Causes skin irritation
Health H340 May cause genetic defects
Precautionary Statement:
 Keep away from heat/sparks/open flames/hot surfaces - No smoking. Pressurized container - Do not pierce or burn, even after use. Specific treatment (see ... on this label). Store locked up. Protect from sunlight. Do not expose to temperatures exceeding 50 °C/122 °F. Dispose of contents/container to in accordance with local/regional/national/international regulations..  

GHS Precautionary Statement Codes for This Product

Statement
Type
Statement
Code
Statement Text
Prevention P210 Keep away from heat/sparks/open flames/hot surfaces - No smoking
Prevention P251 Pressurized container - Do not pierce or burn, even after use
Response P321 Specific treatment (see ... on this label)
Storage P405 Store locked up
Storage P410+412 Protect from sunlight. Do not expose to temperatures exceeding 50 °C/122 °F
Disposal P501 Dispose of contents/container to in accordance with local/regional/national/international regulations.

Potential Health Effects

Eye Contact:Irritating to eyes. Causes serious eye irritation
 
Skin Contact:Harmful in contact with skin
 
Inhalation:Harmful by inhalation
 
Ingestion:May cause lung damage if swallowed.
 
Pressurized container: protect from sunlight and do not expose to temperatures exceeding 50 deg C. Do not pierce or burn, even after use. Keep out of reach of children.
 

Section 3 - Composition/Information on Ingredients

Component CAS # ENIECS REACH Reg. No. Amount
 
Petroleum gases, liquefied, sweetened 68476-86-8 13-30%
Solvent Naphtha (petroleum), light aliph 64742-95-6 60-70%
Xylene 1330-20-7 13-30%

Section 4 - First Aid Measures

Eye Contact: Rinse opened eye for several minutes under running water. If symptoms persist, consult a doctor.
 
Skin Contact: Generally the product does not irritate the skin.
 
Inhalation: Supply fresh air. If required, provide artificial respiration. Keep patient warm. Consult doctor if symptoms persist. In case of unconciousness, place patient stable in side position for transportation.
 
Ingestion: If symptoms persist consult doctor.
 
Medical Conditions Aggravated by Exposure: Bronchitis, CNS Disorders, allergies, nausea.
 

Section 5 - Firefighting Measures

Extinguishing Media: CO2, sand, extinguishing powder. Do not use water.
 
Special Protective Equipment for Firefighters: Mouth respiratory protective device.
 

Section 6 - Accidental Release Measures

Steps to be Taken if Material is Released or Spilled: Dispose contaminated material as waste according to Section 13. Ensure adequate ventilation. Do not flush with water or aqueous cleansing agents.
 
Personal Precautions: Wear protective equipment. Keep unprotected persons away.
 
Environmental Precautions: Do not allow product to reach sewage system or any water course. Inform respective authorites in case of seepage into water course or sewage system
 

Section 7 - Handling and Storage

General Handling: Ensure good ventilation/exhaustion at the workplace. Open and handle receptacle with care. Do not spray on a naked flame or any incandescent material. Keep ignition sources away. Do not smoke. Protect against electrostatic charges. Keep respiratory protective device available. Pressurized container: protect from sunlight and do not expose to temperatures exceeding 50°C (122°F), i.e. electric lights. Do not pierce or burn, evan after use.
 
Other Precautions:
 
Storage: Requirements to be met by storerooms and receptacles: Observe official regulations on storing packagings with presurized containers. Store in cool location. Information about storage in one common storage facility: Not required. Further information about storage conditions: Keep receptacle tightly sealed. Do not gas tight seal receptacle. Store in cool, dry conditions in well sealed reseptacles. Protect from heat and direct sunlight.
 

Section 8 - Precautions to Control Exposure / Personal Protection

ComponentSourceTypeValueRemarks

Personal Protective Equipment (PPE):

Eye/Face Protection: Tightly sealed goggles.
 
Skin Protection: Protective gloves
 
Respiratory Protection: In case of brief exposure or low pollution, use respiratory filter device. In case of intensive or longer exposure, use respiratory protective device that is independent of circulation air.
 
Hygenic Measures: Keep away from foodstuffs, beverages and feed. Immediately remove all soiled and contaminated clothing. Wash hands before break and at the end of work. Avoid contact with the eyes and skin.
 
Engineering Controls: Provide exhaust ventilation or other engineering controls to keep the airborne concentrations of vapors below their threshhold limit value.
 


Section 9 - Physical and Chemical Properties

Appearance: Aerosol
 
Color: Clear
 
Odor: Characteristic
 
ph: Not determined
 
Flash Point: -103C (-153F)
 
Upper Flammable Limit: 9.5% Vol
 
Lower Flammable Limit: 0.7% Vol
 
Autoignition Temperature: Product is not self igniting
 
Vapor Pressure: 6.7 hPa at 20°C (68°F)
 
Boiling Point: <-17°C (< 1°F)
 
Vapor Density: 0.72 g/cm3 at 20° C (68° F)
 
Specific Gravity: Not determined.
 
Freezing Point: Not determined
 
Melting Point: Undetermined
 
Solubility in Water: Fully miscible.
 
Evaporation Rate: Not applicable
 
Partition Coefficient: Not determined
 
Decomposition Temperature: Not determined
 
Percent Volitiles: 100%
 
Percent Solids By Weight: 0%
 
Percent Solids By Volume: 0%
 
Volitile Organic Compounds (VOC): 713 g/l (5.95 lb/gal)
 
Visosity: Not determined

Section 10 - Stability and Reactivity

Conditions To Avoid: No decomposition if used according to specifications.
 
Incompatible Materials: No further relevant information available.
 
Hazardous Decomposition Products: No dangerous decomposition known.
 

Section 11 - Toxicological Information

Ingestion Toxicity: LD50 >6800 mg/kg (rat)
Skin Absorption:LD50 >3000 mg/kg (rat)
Inhalation
LC50/4 h >14mg/l (rat)
 
Sensitization
No sensitizing effects known
 
Chronic Toxicity and Carcinogenicity
3 for xylene, (IARC)
 
Eye Irritation
No irritating effect.
 
Skin Irritation
No irritant effect.
 

Section 12 - Ecological Information

ECOTOXICITY
Do not allow product to reach ground water, water course or sewage system, even in small quantities. Danger to drinking water if even extremely small quantities leak into the ground.
 

Section 13 - Disposal Considerations

Disposal Method:
Must not be disposed of together with household garbage. Do not allow product to reage sewage system.
 
Container Disposal: Disposal must be made according to official regulations.
 

Section 14 - Transport Information

DOT

Proper Shipping Name: Aerosols, flammable
 
Hazard Class: 2.1
 
ID Number: UN1950
 
Packing Group: II
 

IMDG (Maritime transport)

IMDG Class: 2.1
 
UN Number: UN1950
 
Label: Flammable Gas
 
EMS Number: F-D,S-U
 
Maritime Marine Pollutant: No
 
Proper Shipping Name: AEROSOLS
 

IATA (Air Transport)

ICAO/IATA Class: 2.1
 
UN/ID Number: UN1950
 
Label: Flammable Gas
 
Proper Shipping Name: Aerosols, flammable
 

Section 15 - Regulatory Information

Superfund Amendments and Reathorization Act of 1986 (Emergency Planning and Community Right-to-Know Act of 1986) Sections 311 and 312

The following table list hazardous components and the regulatory lists for which they are required to be reported.

Component: Xylene
CAS Number: 1330-20-7
Amount: 10-25%
Xylene is listed in SARA 313
Xylene is known to the State of California to cause cancer.
Xylene is listed with Pennsylvania Right to Know.
Xylene is listed with Comprehensive Environmental Response, Compensation, and Liability Act (CERCLA).
Xylene is listed with the Environmental Protection Agency (EPA) as a possible carcinogen.
Xylene is listed with the Internation Agency for Research on Cancer (IARC) as a possible carcinogen.
Xylene is listed with the American Conference on Governmental Industrial Hygenists (ACGIH) as a possible carcinogen.

HMIS Rating (Scale 0 - 4)

HEALTH  2  Health = 2
FIRE  4  Fire = 4
PHYSICAL  1  Physical = 1
PERSONAL PROTECTION G Personal Protection = G

NFPA Ratings

 4 
2 0
Health = 2
Fire = 4
Reactivity =0

Section 16 - Other Information

Legend

DISCLAIMER
This Safety Data Sheet (SDS) is prepared in compliance with GHS Hazcom 2012. The information may be based in part on information provided by component suppliers and is believed to be correct as of the date hereof. However, no warranty or merchantability, fitness for any use, or any other warranty is expressed or is to be implied regarding the accuracy of of this data, the results to be obtained from the use of the material, or the hazards connected with such use. Since the information contained herein my be applied under conditions beyond our control and with which we may be unfamiliar, and since data made available subsequent to the date hereof may suggest modification of the information, we assume no responsibility for the result of its use. This information and material is furnished on the condition that the person receiving it shall make his/her own determination as the the suitability of the material for his/her particular purpose and on the condition that he/she assume the risk of his/her use thereof.