Safety Data Sheet

According to GHS (Global Harmonized System) - Hazcom 2012
Date Printed (YYYY-MM-DD): 2016-05-09 

Section 1 - Product and Company Information

Product Name: Super Prep Plastic Cleaner
Product Part Number(s): 1000-1, 1000-4
Recommended Use: The product is used to clean plastic prior to repairing the plastic.
Revision Date (YYYY-MM-DD):

COMPANY IDENTIFICATION:EMERGENCY TELEPHONE NUMBER
Polyvance24 Hour Emergency ContactChemtrec - 1-800-424-9300 (Outside USA 703-527-3887)
1128 Kirk Rd.Customer Information Number256-638-4103 (7AM - 4PM (CST) M-F)
Rainsville, AL 35986
Information Email: info@polyvance.com

Section 2 - Hazards Identification

Appearance:Clear liquid
Odor:Petroleum odor
Hazard Statement:
 WARNING! Flammable liquid and vapor. Harmful if swallowed. May cause an allergic skin reaction. May be harmful if inhaled.  

Signal Word:  

WARNING!
Signal Word Hazard:   Flammable liquid and vapor
GHS Physical Hazard PictogramsGHS Health Hazard PictogramsGHS Environmental Hazard Pictograms

Flammable

Irritant
 
Not Applicable

GHS Hazards Statement Codes for This Product

Statement
Type
Statement
Code
Statement Text
Physical H226 Flammable liquid and vapor
Health H302 Harmful if swallowed
Health H317 May cause an allergic skin reaction
Health H333 May be harmful if inhaled
Precautionary Statement:
 Keep away from heat/sparks/open flames. No smoking. Do not spray on an open flame or other ignition source. IF SWALLOWED: Immediately call a POISON CENTER or doctor/physician. IF ON SKIN: Wash with soap and water. IF INHALED: If breathing is difficult, remove victim to fresh air and keep at rest in a position comfortable for breathing. Store in a well ventilated place. Keep container tightly closed.  

GHS Precautionary Statement Codes for This Product

Statement
Type
Statement
Code
Statement Text
Prevention P210 Keep away from heat/sparks/open flames. No smoking
Prevention P211 Do not spray on an open flame or other ignition source
Response P301+310 IF SWALLOWED: Immediately call a POISON CENTER or doctor/physician
Response P302+352 IF ON SKIN: Wash with soap and water
Response P304+341 IF INHALED: If breathing is difficult, remove victim to fresh air and keep at rest in a position comfortable for breathing
Response P305+351+338 IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses if present and easy to do continue rinsing
Storage P403+233 Store in a well ventilated place. Keep container tightly closed

Potential Health Effects

Eye Contact:Severe irritation, tearing, redness, and blurred vision.
 
Skin Contact:Prolonged contact may cause slight irritation with local redness. May cause drying and flaking of the skin.
 
Inhalation:Dizziness, difficulty breathing, headaches, and loss of coordination.
 
Ingestion:Can cause gastrointestinal irritation, vomiting, nausea, and diarrhea.
 
Repeated Exposure:Xylene is reported to have caused hearing loss in laboratory animals upon exposure to high concentrations; such effects have not been reported in humans.
 

Section 3 - Composition/Information on Ingredients

Component CAS # ENIECS REACH Reg. No. Amount
 
Heptane 142-82-5 5-10%
Isopropyl Alcohol 67-63-0 20-25%
VM&P Naphtha 64742-89-8 65-70%
Xylene 1330-20-7 5-10%

Section 4 - First Aid Measures

Eye Contact: Remove any contact lenses. Flush with plenty of water for 15 minutes. Get immediate medical attention.
 
Skin Contact: Remove contaminated clothing including shoes and immediately was affected area with plenty of soap and water. If irritation occurs, seek medical attention.
 
Inhalation: Remove from further exposure. Keep warm and at rest. If not breathing, give artificial respiration. If breathing is difficult, trained personnel should administer oxygen. Seek medical attention.
 
Ingestion: Wash out mouth with water, keep at rest. Seek medical attention. Do NOT induce vomiting unless directed to do so by medical personnel.
 
Medical Conditions Aggravated by Exposure: Anesthesia, respiratory tract irritation, dermatitis, nausea, and vomiting.
 

Section 5 - Firefighting Measures

Extinguishing Media: Foam, CO2, Chemical, Water Fog
 
Fire Fighting Procedures: Respiratory equipment should be worn to avoid inhalation of concentrated vapors. Water should not be used except as a fog to keep nearby containers cool.
 
Special Protective Equipment for Firefighters: Respiratory and eye protection are required for fire fighting personnel. Full protective equipment (Bunker Gear) and self contained breathing apparatus (SCBA) should be used for all indoor fires and any significant outdoor fires. For small outdoor fires, which may easily be extinguished with a portable fire extinguisher, use of a SCBA may not be required.
 
Unusual Fire and Explosion Hazards: Handle as a flammable liquid. Vapors form and explosive mixture in air between lower and upper explosive limits which can be ignited by many sources such as pilot lights, open flames, electric motors and switches.
 

Section 6 - Accidental Release Measures

Steps to be Taken if Material is Released or Spilled: Eliminate ignition sources. Allow volitile portion to evaporate completely. Avoid breathing vapors and remove with inert absorbent.
 
Personal Precautions:
 
Environmental Precautions:
 

Section 7 - Handling and Storage

General Handling: Reports have associated repeated and prolonged occupational overexposure to solvents with permanent brain and nervous system damage. Intentional misuse by deliberately concentrating and inhaling the contents may be harmful or fatal. Avoid spontaneous combustion of contaminated rags or other ignitible material by immediate immersion in water. Keep out of reach of children.
 
Other Precautions:
 
Storage: Do not store or use near heat, sparks or flame. Store in well ventilated area. Keep closure tight and container upright to prevent leakage. Do not spray near fire or open flame.
 

Section 8 - Precaustions to Control Exposure / Personal Protection

ComponentSourceTypeValueRemarks
Aliphatic Petroleum NaphthasOSHAPEL400 ppmSTEL
Aliphatic Petroleum NaphthasACGIHTLV300 ppmTWA
Aliphatic Petroleum NaphthasOSHAPEL300 ppmTWA
HeptaneACGIHTLV500 ppmSTEL
HeptaneACGIHTLV400 ppmTWA
HeptaneOSHAPEL500 ppmTWA
HeptaneOSHAPEL500 ppmSTEL
Isopropyl AlcoholACGIHTLV400 ppmSTEL
Isopropyl AlcoholACGIHTLV200 ppmTWA
Isopropyl AlcoholOSHAPEL400 ppmTWA
Isopropyl AlcoholOSHAPEL500 ppmSTEL
XyleneOSHAPEL150 ppmSTEL
XyleneOSHAPEL100 ppmTWA
XyleneACGIHTLV150 ppmSTEL
XyleneACGIHTLV100 ppmTWA

Personal Protective Equipment (PPE):

Eye/Face Protection: Goggles or side-shielded safety glasses.
 
Skin Protection: Neoprene or butyl rubber gloves.
 
Respiratory Protection: Use of a NIOSH approved chemical/mechanical filter, designed to remove a combination of particles and vapors.
 
Hygenic Measures: Eye wash stations and safety showers in the workplace are recommended. Wash hands before eating, smoking or using the washroom.
 
Other Protection Measures: To prevent repeated or prolonged skin contact, wear impervios clothing and boots. Wash contaminated clothing before reuse.
 
Engineering Controls: Provide sufficient mechanical /or local exhaust) ventilation to maintain exposure below TLV(s)
 


Section 9 - Physical and Chemical Properties

Appearance: Clear, petroleum odor
 
Physical State: Liquid
 
Odor: Characteristic
 
ph: Not determined
 
Flash Point: 25°F
 
Upper Flammable Limit: 12.0%
 
Lower Flammable Limit: 0.9%
 
Autoignition Temperature: Not Available
 
Vapor Pressure: Not Available
 
Boiling Point: 181-280°F
 
Vapor Density: Heavier than air
 
Specific Gravity: 0.80
 
Freezing Point: Not Available
 
Melting Point: Not Available
 
Solubility in Water: Not Soluble
 
Evaporation Rate: Not Available
 
Partition Coefficient: Not Available
 
Heat Value: Not available
 
Particle Size: Not available
 
Decomposition Temperature: Not Available
 
Percent Volitiles: 100
 
Percent Solids By Weight: 0
 
Percent Solids By Volume: 0
 
Volitile Organic Compounds (VOC): 762 g/l (6.36 lb/gl)
 
Visosity: Not Available

Section 10 - Stability and Reactivity

Stability/Instability: Stable
 
Conditions To Avoid: Excessive heat, poor ventilation, open flames, sources of sparks.
 
Incompatible Materials: Alkaline materials, strong acids, and oxidizing materials.
 
Hazardous Polymerization: Will Not Occur
 
Hazardous Decomposition Products: Carbon monoxide, carbon dioxide, various hydrocarbons, oxides of nitrogen, and possibly acrolein.
 

Section 11 - Toxicological Information

Ingestion Toxicity: 5-10%
Skin Absorption:5-10%
Inhalation
5-10%
 
Neurological
Not available
 
Genetic Toxicity
Not available
 

Section 12 - Ecological Information

No Ecological Information available

Section 13 - Disposal Considerations

Disposal Method:
Do not incinerate. Dispose of in accordance with local, state, and federal regulations. Do not contaminate lakes, streams or other water supply.
 
Container Disposal: Disposal must be made according to official regulations.
 

Section 14 - Transport Information

DOT

Proper Shipping Name: Paint Related Material, NOI, Limited Quantity
 
Hazard Class: 3
 
ID Number: UN1263
 
Packing Group: II
 

IMDG (Maritime transport)

IMDG Class: 3
 
UN Number: UN1263
 
Label: Flammable Liquid
 
Packaging Group: II
 
EMS Number: F-E, S-E
 
Maritime Marine Pollutant: No
 
Proper Shipping Name: Paint Related Material
 

IATA (Air Transport)

ICAO/IATA Class: 3
 
UN/ID Number: UN1263
 
Label: Flammable Liquid
 
Air Packaging Group: II
 
Proper Shipping Name: Paint Related Material
 

Section 15 - Regulatory Information

Superfund Amendments and Reathorization Act of 1986 (Emergency Planning and Community Right-to-Know Act of 1986) Sections 311 and 312

The following table list hazardous components and the regulatory lists for which they are required to be reported.

Component: VM&P Naphtha
CAS Number: 64742-89-8
Amount: 65-70%
VM&P Naphtha is known to the State of California to cause cancer.
VM&P Naphtha is listed with Pennsylvania Right to Know.
VM&P Naphtha is listed with New Jersey Right to Know.

Component: Heptane
CAS Number: 142-82-5
Amount: 5-10%
Heptane is listed with Massachusetts Right to Know.
Heptane is listed with Rhode Island Right to Know.
Heptane is listed with Illinois toxic substances discloure to employee act.

Component: Isopropyl Alcohol
CAS Number: 67-63-0
Amount: 20-25%
Isopropyl Alcohol is listed with Pennsylvania Right to Know.
Isopropyl Alcohol is listed with Massachusetts Right to Know.
Isopropyl Alcohol is listed with Rhode Island Right to Know.
Isopropyl Alcohol is listed with Illinois toxic substances discloure to employee act.

Component: Xylene
CAS Number: 1330-20-7
Amount: 5-10%
Xylene is listed in SARA 313
Xylene is listed with Pennsylvania Right to Know.
Xylene is listed with Massachusetts Right to Know.
Xylene is listed with Rhode Island Right to Know.
Xylene is listed with New Jersey Right to Know.
Xylene is listed with Comprehensive Environmental Response, Compensation, and Liability Act (CERCLA).
Xylene is listed with the Environmental Protection Agency (EPA) as a possible carcinogen.
Xylene is listed with the Internation Agency for Research on Cancer (IARC) as a possible carcinogen.
Xylene is listed with the American Conference on Governmental Industrial Hygenists (ACGIH) as a possible carcinogen.

HMIS Rating (Scale 0 - 4)

HEALTH  2  Health = 2
FIRE  3  Fire = 3
PHYSICAL  1  Physical = 1
PERSONAL PROTECTION G Personal Protection = G

NFPA Ratings

 3 
2 0
Health = 2
Fire = 3
Reactivity =0

Section 16 - Other Information

Legend
CASChemical Abstract Service
CFRCode of Federal Regulations
EINECSEuropean Inventory of Existing Commercial Chemical Substances
EPAEnvironmental Protection Agency
HMISHazardous Materials Identification System
IARCInternational Agency for Research on Cancer
MSDSMaterial Safety Data Sheet
NFPANational Fire Protection Association
NIOSHNational Institute for Occupational Safety and Health
NTPNational Toxicology Program
OELOccupational Exposure Limit
OSHAOccupational Safety and Health Administration
PELPermissible Exposure Limit
REACHRegistration, Evaluation, Authorisation and Restriction of Chemicals
RELRecommended Exposure Level
STELShort Term Exposure Limit
TLVThreshold Limit Value
TWATime Weighted Average

DISCLAIMER
This Safety Data Sheet (SDS) is prepared in compliance with GHS Hazcom 2012. The information may be based in part on information provided by component suppliers and is believed to be correct as of the date hereof. However, no warranty or merchantability, fitness for any use, or any other warranty is expressed or is to be implied regarding the accuracy of of this data, the results to be obtained from the use of the material, or the hazards connected with such use. Since the information contained herein my be applied under conditions beyond our control and with which we may be unfamiliar, and since data made available subsequent to the date hereof may suggest modification of the information, we assume no responsibility for the result of its use. This information and material is furnished on the condition that the person receiving it shall make his/her own determination as the the suitability of the material for his/her particular purpose and on the condition that he/she assume the risk of his/her use thereof.